Recalls

Find the latest 2009 Toyota Prius recalls as issued by the National Highway Traffic Safety Administration (NHTSA) and Manufacturers.

Component ENGINE AND ENGINE COOLING
Component EQUIPMENT:OTHER:LABELS
Component STEERING
Component VEHICLE SPEED CONTROL:ACCELERATOR PEDAL
Consequence A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Consequence A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Consequence Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Consequence The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Consequence THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Mfg's Report Date JAN 26, 2010
Mfg's Report Date NOV 14, 2012
Mfg's Report Date OCT 01, 2009
Mfg's Report Date OCT 05, 2009
NHTSA CAMPAIGN ID 09V388000
NHTSA CAMPAIGN ID 10V035000
NHTSA CAMPAIGN ID 10V036000
NHTSA CAMPAIGN ID 12V536000
NHTSA CAMPAIGN ID 12V537000
Notes OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV .
Notes Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Potential Number of Units Affected 153418
Potential Number of Units Affected 271417
Potential Number of Units Affected 350,662
Potential Number of Units Affected 3800000
Potential Number of Units Affected 669,705
Remedy DEALERS WILL REPLACE THE CERTIFICATION LABEL, THE TIRE AND LOADING INFORMATION LABEL, AND THE LOAD CARRYING CAPACITY MODIFICATION (ADDENDUM) LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING MAY 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Remedy DEALERS WILL REPLACE THE LOAD CARRYING CAPACITY MODIFICATION (ADDENDUM) LABEL FREE OF CHARGE. THE RECALL EXPECTED TO BEGIN DURING MAY 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-954-420-2000.
Remedy Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Remedy Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall is expected to begin in December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Remedy TOYOTA WILL NOTIFY OWNERS OF AFFECTED VEHICLES TO REMOVE ANY DRIVER'S FLOOR MAT AND NOT REPLACE IT WITH ANY OTHER FLOOR MAT PENDING THE DEVELOPMENT OF MODEL-SPECIFIC REMEDIES. TOYOTA WILL MAIL A SECOND NOTIFICATION TO OWNERS OF AFFECTED VEHICLES NOTIFYING THEM OF THE FREE REMEDY WHEN IT IS AVAILABLE. THE FIRST NOTICE IS EXPECTED TO BE MAILED DURING OCTOBER 2009 AND TOYOTA WILL ADVISE NHTSA OF THE ESTIMATED DATE WHEN THE REMEDY PARTS WILL BE AVAILABLE. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331, LEXUS AT 1-800-255-3987.
Summary GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Summary SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2006-2009 SIENNA PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Summary Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Summary Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Summary TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
Component ENGINE AND ENGINE COOLING
Component EQUIPMENT:OTHER:LABELS
Component STEERING
Component VEHICLE SPEED CONTROL:ACCELERATOR PEDAL
Consequence A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Consequence A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Consequence Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Consequence The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Consequence THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Mfg's Report Date JAN 26, 2010
Mfg's Report Date NOV 14, 2012
Mfg's Report Date OCT 01, 2009
Mfg's Report Date OCT 05, 2009
NHTSA CAMPAIGN ID 09V388000
NHTSA CAMPAIGN ID 10V035000
NHTSA CAMPAIGN ID 10V036000
NHTSA CAMPAIGN ID 12V536000
NHTSA CAMPAIGN ID 12V537000
Notes OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV .
Notes Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Potential Number of Units Affected 153418
Potential Number of Units Affected 271417
Potential Number of Units Affected 350,662
Potential Number of Units Affected 3800000
Potential Number of Units Affected 669,705
Remedy DEALERS WILL REPLACE THE CERTIFICATION LABEL, THE TIRE AND LOADING INFORMATION LABEL, AND THE LOAD CARRYING CAPACITY MODIFICATION (ADDENDUM) LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING MAY 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Remedy DEALERS WILL REPLACE THE LOAD CARRYING CAPACITY MODIFICATION (ADDENDUM) LABEL FREE OF CHARGE. THE RECALL EXPECTED TO BEGIN DURING MAY 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-954-420-2000.
Remedy Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Remedy Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall is expected to begin in December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Remedy TOYOTA WILL NOTIFY OWNERS OF AFFECTED VEHICLES TO REMOVE ANY DRIVER'S FLOOR MAT AND NOT REPLACE IT WITH ANY OTHER FLOOR MAT PENDING THE DEVELOPMENT OF MODEL-SPECIFIC REMEDIES. TOYOTA WILL MAIL A SECOND NOTIFICATION TO OWNERS OF AFFECTED VEHICLES NOTIFYING THEM OF THE FREE REMEDY WHEN IT IS AVAILABLE. THE FIRST NOTICE IS EXPECTED TO BE MAILED DURING OCTOBER 2009 AND TOYOTA WILL ADVISE NHTSA OF THE ESTIMATED DATE WHEN THE REMEDY PARTS WILL BE AVAILABLE. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331, LEXUS AT 1-800-255-3987.
Summary GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Summary SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2006-2009 SIENNA PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Summary Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Summary Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Summary TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
Component ENGINE AND ENGINE COOLING
Component EQUIPMENT:OTHER:LABELS
Component STEERING
Component VEHICLE SPEED CONTROL:ACCELERATOR PEDAL
Consequence A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Consequence A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Consequence Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Consequence The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Consequence THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Mfg's Report Date JAN 26, 2010
Mfg's Report Date NOV 14, 2012
Mfg's Report Date OCT 01, 2009
Mfg's Report Date OCT 05, 2009
NHTSA CAMPAIGN ID 09V388000
NHTSA CAMPAIGN ID 10V035000
NHTSA CAMPAIGN ID 10V036000
NHTSA CAMPAIGN ID 12V536000
NHTSA CAMPAIGN ID 12V537000
Notes OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV .
Notes Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Potential Number of Units Affected 153418
Potential Number of Units Affected 271417
Potential Number of Units Affected 350,662
Potential Number of Units Affected 3800000
Potential Number of Units Affected 669,705
Remedy DEALERS WILL REPLACE THE CERTIFICATION LABEL, THE TIRE AND LOADING INFORMATION LABEL, AND THE LOAD CARRYING CAPACITY MODIFICATION (ADDENDUM) LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING MAY 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Remedy DEALERS WILL REPLACE THE LOAD CARRYING CAPACITY MODIFICATION (ADDENDUM) LABEL FREE OF CHARGE. THE RECALL EXPECTED TO BEGIN DURING MAY 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-954-420-2000.
Remedy Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Remedy Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall is expected to begin in December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Remedy TOYOTA WILL NOTIFY OWNERS OF AFFECTED VEHICLES TO REMOVE ANY DRIVER'S FLOOR MAT AND NOT REPLACE IT WITH ANY OTHER FLOOR MAT PENDING THE DEVELOPMENT OF MODEL-SPECIFIC REMEDIES. TOYOTA WILL MAIL A SECOND NOTIFICATION TO OWNERS OF AFFECTED VEHICLES NOTIFYING THEM OF THE FREE REMEDY WHEN IT IS AVAILABLE. THE FIRST NOTICE IS EXPECTED TO BE MAILED DURING OCTOBER 2009 AND TOYOTA WILL ADVISE NHTSA OF THE ESTIMATED DATE WHEN THE REMEDY PARTS WILL BE AVAILABLE. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331, LEXUS AT 1-800-255-3987.
Summary GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Summary SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2006-2009 SIENNA PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Summary Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Summary Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Summary TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.

Powered by Chrome