Car Problems ›› 2007 CHEVROLET COBALT Problems

Show Filter
 
Page 1
Next >>  
Year Make Model Type Date
2007 CHEVROLET COBALT Defect Investigation Open 2010/01/27 - Close 2010/07/19 NHTSA #: PE10005
NHTSA Recall #: 10V073000
STEERING:ELECTRIC POWER ASSIST SYSTEM: In a March 1, 2010 letter, General Motors Corporation (GM) provided a defect information report to NHTSA regarding a problem that could result in sudden loss of power steering assist in certain model year (MY) 2005 through 2010 Chevrolet Cobalt and MY 2007 through 2010 Pontiac G5 vehicles equipped with electric power steering (EPS).The letter indicates that the loss of steering assist could occur at any time while driving and that, once assist is lost, a message is displayed on the Driver Information Center (DIC) and a chime sounds to inform the driver.The letter further states that steering control is maintained in manual mode, but would require greater driver effort at low vehicle speeds.In the next ignition cycle, power assist is typically regained and the DIC message is no longer displayed.GM's letter identifies the root cause of the EPS failure as the EPS motor and indicates that production of a new motor started in December 2009.GM's recall repair procedure instructs dealers to replace the EPS motor in all recalled vehicles. ODI's analysis of all information available related to sudden loss of EPS assist while driving in the MY 2005 through 2009 Chevrolet Cobalt vehicles shows current complaint and warranty rates of 323/100,000 vehicles and 0.4% respectively.In response to ODI's request for information, GM identified 81 complaints where a crash was claimed that may be related to loss of EPS assist.ODI's analysis of all crash claims was based on verifiable factors such as; whether a loss of EPS was indicated at the time of the crash by a chime or malfunction indicator lamp or if a EPS related component malfunction was identified after the crash occurred.With this method ODI identified 36 possible crashes related to EPS failure.GM assessed crash claims based on the available facts and excluded crash claims that indicated that the vehicle was travelling at speeds in the range of 30 mph or greater.GM said that it believes if power assist is lost while a vehicle is moving at speeds in the range of 30 mph or greater there is a small difference in steering efforts perceived in subjective evaluations at those speeds and it is unlikely to lead to loss of vehicle control. Based on GM's safety recall, this investigation is closed.
2007 CHEVROLET COBALT Technical Service Bulletin 2013/04/01 NHTSA #: 10033024
Service Bulletin #: SB-09275
FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP: SATURN/PONTIAC/CHEVROLET: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. SPECIAL COVERAGE ADJUSTMENT; FUEL ODOR OR SPOTTING ON GROUND; REPLACE FUEL PUMP MODULE. SOME VEHICLES MAY HAVE A CONDITION IN WHICH THE PLASTIC SUPPLY OR RETURN PORT
2007 CHEVROLET COBALT Technical Service Bulletin 2013/04/01 NHTSA #: 10033024
Service Bulletin #: SB-09275
FUEL SYSTEM, OTHER:DELIVERY:FUEL PUMP: SATURN/PONTIAC/CHEVROLET: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. SPECIAL COVERAGE ADJUSTMENT; FUEL ODOR OR SPOTTING ON GROUND; REPLACE FUEL PUMP MODULE. SOME VEHICLES MAY HAVE A CONDITION IN WHICH THE PLASTIC SUPPLY OR RETURN PORT
2007 CHEVROLET COBALT Technical Service Bulletin 2013/02/01 NHTSA #: 10025669
Service Bulletin #: 08-09-41-006
AIR BAGS:FRONTAL: SIR/AIR BAG LIGHT ILLUMINATED, DTC B0081 (PASSENGER PRESENCE SYSTEM (PPS) CODE) STORED (INSPECT PPS SYSTEM CONNECTORS). *PE UPDATED 5/22/09. *PE UPDATED 4/22/13. *PE
2007 CHEVROLET COBALT Technical Service Bulletin 2013/02/01 NHTSA #: 10051936
Service Bulletin #: SB=12191
FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP: CHEVROLET/PONTIAC/SATURN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. ON FUEL PUMP MODULE, PLASTIC SUPPLY OR RETURN PORT MAY BE CRACK AND WILL DEVELOP A FUEL LEAKAGE WHEREBY FUEL ODOR IS NOTICED, WHEN DRIVEN OR PARKED. PARTS AVAILABILI
2007 CHEVROLET COBALT Technical Service Bulletin 2013/02/01 NHTSA #: 10051936
Service Bulletin #: SB=12191
FUEL SYSTEM, OTHER:DELIVERY:FUEL PUMP: CHEVROLET/PONTIAC/SATURN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. ON FUEL PUMP MODULE, PLASTIC SUPPLY OR RETURN PORT MAY BE CRACK AND WILL DEVELOP A FUEL LEAKAGE WHEREBY FUEL ODOR IS NOTICED, WHEN DRIVEN OR PARKED. PARTS AVAILABILI
2007 CHEVROLET COBALT Technical Service Bulletin 2012/09/01 NHTSA #: 10047261
Service Bulletin #: PI-0817
ELECTRICAL SYSTEM:WIRING: CHEVROLET/PONTIAC/SATURN: ENGINE FAILS TO START AFTER ENGINE CRANKS DUE TO FUEL PUMP WIRE HARNESS CONNECTOR NEEDS REPLACING, WITHOUT REPLACING FUEL PUMP COVER ASSEMBLY (FUEL PUMP FLANGE). MODEL 2007-2010 COBALT, G5, ION. *PE
2007 CHEVROLET COBALT Technical Service Bulletin 2012/09/01 NHTSA #: 10047261
Service Bulletin #: PI-0817
FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP: CHEVROLET/PONTIAC/SATURN: ENGINE FAILS TO START AFTER ENGINE CRANKS DUE TO FUEL PUMP WIRE HARNESS CONNECTOR NEEDS REPLACING, WITHOUT REPLACING FUEL PUMP COVER ASSEMBLY (FUEL PUMP FLANGE). MODEL 2007-2010 COBALT, G5, ION. *PE
2007 CHEVROLET COBALT Technical Service Bulletin 2012/09/01 NHTSA #: 10047360
Service Bulletin #: PIC-5671-C
FUEL SYSTEM, OTHER: CHEVROLET/PONTIAC: FUEL TANK COVER ASSEMBLY (NU6 EMISSION PACKAGE) CAN NOT BE ORDERED THRU DEALERSHIP DUE TO PARTS (25815572 AND 25948766) BEING PLACED ON RETRICTION THRU PRODUCT QUALITY CENTER (PQC). MODELS 2007-2010 COBALT, G5 AND 200
2007 CHEVROLET COBALT Technical Service Bulletin 2012/09/01 NHTSA #: 10047360
Service Bulletin #: PIC-5671-C
FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY: CHEVROLET/PONTIAC: FUEL TANK COVER ASSEMBLY (NU6 EMISSION PACKAGE) CAN NOT BE ORDERED THRU DEALERSHIP DUE TO PARTS (25815572 AND 25948766) BEING PLACED ON RETRICTION THRU PRODUCT QUALITY CENTER (PQC). MODELS 2007-2010 COBALT, G5 AND 200
2007 CHEVROLET COBALT Technical Service Bulletin 2012/06/01 NHTSA #: 10044226
Service Bulletin #: SB-12089
ELECTRICAL SYSTEM:IGNITION: CHEVROLET/PONTIAC: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. A BINDING CONDITION HAS OCCUR BETWEEN THE HOUSING AND IGNITION LOCK CYLINDER WHICH MAKES THE IGNITION KEY DIFFICULT TO TURN OR REMOVE FROM IGNITION. *PE UPDATED 8/1
2007 CHEVROLET COBALT Technical Service Bulletin 2012/06/01 NHTSA #: 10044226
Service Bulletin #: SB-12089
ELECTRICAL SYSTEM:IGNITION:MODULE: CHEVROLET/PONTIAC: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. A BINDING CONDITION HAS OCCUR BETWEEN THE HOUSING AND IGNITION LOCK CYLINDER WHICH MAKES THE IGNITION KEY DIFFICULT TO TURN OR REMOVE FROM IGNITION. *PE UPDATED 8/1
2007 CHEVROLET COBALT Technical Service Bulletin 2012/05/01 NHTSA #: 10044242
Service Bulletin #: PIT5074F
ELECTRICAL SYSTEM: GM: J-35616-64B TERMINAL TEST PROBE AND REPLACEMENT TERMINAL. ALSO INCLUDED MODELS VERANO, REGAL, LACROSSE, CTS, SRX, VOLT, SONIC, MALIBU, IMPALA, EQUINOX, CRUZE, AVALANCHE, TAHOE SUBURBAN, SILVERADO, SIERRA, YUKON, AND TERRAIN FOR MODEL
2007 CHEVROLET COBALT Technical Service Bulletin 2012/04/01 NHTSA #: 10037570
Service Bulletin #: PIT-3749D
STRUCTURE:FRAME AND MEMBERS: GM: ON SOME TRUCK MODELS THERE IS SOME FRAME CORROSION. *RM UPDATED ON 5/2/2012. *KB
2007 CHEVROLET COBALT Technical Service Bulletin 2012/01/01 NHTSA #: 10038294
Service Bulletin #: 09-09-40-001A
SEAT BELTS: GM: THERE ARE SEAT BELT PROBLEMS: DIFFICULTY LATCHING AND UNLATCHING BUCKLE. BUCKLE RELEASE BUTTON IS STICKING. SEAT BELT WARNING LIGHT ILLUMINATED. LIKELY CAUSED BY STICKY BEVERAGES THAT ARE SPILLED INTO THE BUCKLE ASSEMBLY. *RM UPDATED 4/
2007 CHEVROLET COBALT Technical Service Bulletin 2012/01/01 NHTSA #: 10038294
Service Bulletin #: 09-09-40-001A
SEAT BELTS:FRONT:WARNING LIGHT/DEVICES: GM: THERE ARE SEAT BELT PROBLEMS: DIFFICULTY LATCHING AND UNLATCHING BUCKLE. BUCKLE RELEASE BUTTON IS STICKING. SEAT BELT WARNING LIGHT ILLUMINATED. LIKELY CAUSED BY STICKY BEVERAGES THAT ARE SPILLED INTO THE BUCKLE ASSEMBLY. *RM UPDATED 4/
2007 CHEVROLET COBALT Technical Service Bulletin 2011/12/01 NHTSA #: 10029924
Service Bulletin #: SB-08-09-41-002C
AIR BAGS: GENERAL MOTORS: DIAGNOSTIC INFORMATION FOR INTERMITTENT RESTRAINTS, AIR BAG (SIR) INDICATOR/LAMP ON WITH DTC(S) B0012, B0013, B0016, B0016, B0019, B0020, B0022, B0023, B0026, B0033, B0040, B0042 OR B0044 SET. THIS MAY BE CAUSED BY A LOOSE,
2007 CHEVROLET COBALT Technical Service Bulletin 2011/10/01 NHTSA #: 10037184
Service Bulletin #: 05-09-40-002E
SEAT BELTS:FRONT:RETRACTOR: GM: SERVICE BULLETIN EXPLAINING WHEN THE SAFETY BELTS ARE SUPPOSED TO LOCK. *RM UPDATED 12/6/11. *PE
2007 CHEVROLET COBALT Technical Service Bulletin 2011/10/01 NHTSA #: 10037184
Service Bulletin #: 05-09-40-002E
SEAT BELTS:FRONT:WEBBING: GM: SERVICE BULLETIN EXPLAINING WHEN THE SAFETY BELTS ARE SUPPOSED TO LOCK. *RM UPDATED 12/6/11. *PE
2007 CHEVROLET COBALT Technical Service Bulletin 2011/06/01 NHTSA #: 10022806
Service Bulletin #: PIC-4578
ELECTRICAL SYSTEM:FUSES AND CIRCUIT BREAKERS: EPS/STR WHEEL CONTROL FUSE (#19) OPEN. *KB UPDATED 10/04/07. *NJ UPDATED 8/7/09. *PE UPDATED 8/1/11. *PE
 
Page 1
Next >>  
Powered by Chrome